BWRNZ - COMPOUND 1013
- MSDS: BWRNZ
- Manufacturer: MAGNOLIA PLASTICS INC
- Product Name: COMPOUND 1013
- National Stock Number: 8010-00N056844
Product Identification
Product ID:COMPOUND 1013
MSDS Date:02/28/1991
FSC:8010
NIIN:00N056844
MSDS Number: BWRNZ
Responsible Party
CHAMBLEE, GA 30341
US
Emergency Phone: 404-451-2777
Info Phone: 404-451-2777
Cage: 22121
Contractor
Telephone: (770) 451-2777/(800) 457-4280
Cage: 22121
Ingredients
PROPANE, 1-BUTOXY-2,3-EPOXY-; (BUTYL GLYCIDYL ETHER) (BGE)
CAS: 2426-08-6
RTECS: TX4200000
Fraction By Weight: 5-10%
OSHA PEL N/K
ACGIH TLV: 25 PPM (MFR)
PHTHALIC ACID, DIBUTYL ESTER; (DIBUTYL PHTHALATE) (SARA
CAS: 84-74-2
RTECS: TI0875000
Fraction By Weight: 2-5%
OSHA PEL 5 MG/M3
ACGIH TLV: 5 MG/M3
EPA Report Quantity: 10 LBS
DOT Report Quantity: 10 LBS
Hazards
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MODERATELY IRRITATING TO SKIN &
EYES. POSSIBLE SKIN SENSITIZER. CHRONIC:PRE-EXISTING SKIN & EYE
DISORDERS MAY BE AGGRAVATED. RTES OF EXPOS:INHAL:NOT LIKELY TO
PRODUCE ADVERSE EFFECT DUE TO LOW V OLATILITY. INGEST:LOW ORDER OF
TOXICITY. SKIN ABSORPTION:NOT LIKELY TO BE ABSORBED IN TOXIC
AMOUNTS. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:EYE:MODERATELY IRRITATING.
SKIN:MODERATELY IRRITATING. MAY CAUSE SKIN SENSITIZATION.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN & EYE DISORDERS
MAY BE AGGRAVATED.
First Aid
First Aid:SKIN:REMOVE CONTAMINATED CLOTHING. WASH FROM SKIN WITH SOAP
AND WATER. LAUNDER CLOTHING PRIOR TO RE-USE. EYES:FLUSH WITH WATER
FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN. GET MEDICAL ATTENTION.
INHALAT ION:REMOVE VICTIM TO FRESH AIR. ADMINISTER OXYGEN IF
NECESSARY. INGESTION:DO NOT INDUCE VOMITING. GIVE LARGE DOSES OF
WATER. GET MEDICAL ATTENTION.
Fire Fighting
Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . AVOID BREATHING SMOKE. COOL FIRE EXPOSED
CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:NONE.
Accidental Release
Spill Release Procedures:AVOID CONTACT WITH LIQUID AND VAPORS. WIPE
WITH A CLOTH OR COLLECT ON ABSORBENT MATERIAL. LARGE SPILLS:DIKE
AND CONTAIN. PUMP OR SHOVEL INTO SALVAGE VESSELS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
Handling
Handling and Storage Precautions:STORE IN COOL, DRY AREA IN TIGHTLY
CLOSED CONTAINERS. AVOID CONTACT WITH SKIN AND EYES. USE WITH
ADEQUATE VENTILATION.
Other Precautions:FOR INDUSTRIAL USE ONLY. MAY CAUSE SKIN IRRITATION.
Exposure Controls
Respiratory Protection:FOR EXCESSIVE VAPORS OR TO MAINTAIN BELOW TLV
LIMIT. NIOSH/MSHA (SPECIFY TYPE) APPROVED RESPIRATOR FOR ORGANIC
VAPORS IN COMPLIANCE WITH 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST:YES. MECHANICAL (GENERAL):YES.
Protective Gloves:IMPERVIOUS RUBBER GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:FOR PROLONGED EXPOSURE, IMPERVIOUS CLOTHING
AND BOOTS TO MINIMIZE PERSONAL CONTACT. EYE-WASH STATION, SAFETY
SHOWER.
Work Hygienic Practices:USE GOOD HYGIENE PRACTICES.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.
Chemical Properties
Boiling Pt:B.P. Text:>225F,>107C
Vapor Pres:NIL
Vapor Density:>1
Spec Gravity:1.55 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY VISCOUS LIQUID
Percent Volatiles by Volume:0
Stability
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:ELEVATED TEMPERATURES. REACTION WITH SOME
CURING AGENTS IN BULK AMOUNTS IS EXOTHERMIC.
Hazardous Decomposition Products:CO, ALDEHYDES, ACIDS.
Disposal
Waste Disposal Methods:CURE, THEN BURY OR INCINERATE WHERE PERMITTED BY
FEDERAL, STATE AND LOCAL REGULATIONS. REMOVE SALVAGE VESSELS TO A
WASTE DISPOSAL SITE OPERATING IN COMPLIANCE WITH FEDERAL, STATE AND
LOCAL REGUALTIONS .
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.